Net energy-oriented agitation optimization for cow manure–corn straw co-fermentation
Abstract
This study systematically investigated the evolution law of rheological properties in the anaerobic fermentation system of cow manure (CM) and corn straw (CS) mixtures at varying total solids (TS). Combined with computational fluid dynamics (CFD) simulations, the distribution characteristics of particles within fermentation system were revealed, illustrating the impact mechanisms of agitation strategies. Simulations demonstrated that higher agitation speeds and TS levels increase instantaneous power consumption while altering mixing and sedimentation dynamics. When TS was 6%, 120 r/min required more power than 100 r/min and 80 r/min, but 100 r/min reduced daily energy consumption by 4.30% and 3.19% compared to 80 r/min and 120 r/min. Under conditions of TS=6% and 8%, with maintained process stability, experimental groups increased energy output by 12.42% and 30.41% while reducing energy consumption by 13.60% and 3.39% versus control groups, demonstrating significant overall efficiency gains. Inversely, when TS was 10%, experimental groups decreased energy output by 0.34%, while increasing energy consumption. These findings prove that when TS is below 10%, optimized agitation strategies enable positive net energy output, establish an optimization scheme, and balance biogas production efficiency with economic feasibility.
Keywords: anaerobic digestion; rheological properties; agitation strategies; net energy
DOI: 10.25165/j.ijabe.20261903.10379
Citation: Liu Y Y N, Zhang K J, Sun Y. Net energy-oriented agitation optimization for cow manure–corn straw co-fermentation. Int J Agric & Biol Eng, 2026; 19(3): 281–293.
References
[1] Chen X T, Cui Z J, Zhao Y H, Zhu N, Liu Y, Hu Z H, et al. Synergistic mechanism of substrate hydrolysis and methanogenesis under “gradient anaerobic digestion” process. Energy Conversion and Management, 2024; 309: 118443.
[2] Tsafrakidou P, Bekatorou A, Koutinas A A, Kordulis C, Banat I M, Petsi T, et al. Αcidogenic fermentation of wheat straw after chemical and microbial pretreatment for biofuel applications. Energy Conversion and Management, 2018; 160: 509–517.
[3] Wang X G, Liu T Q, Liu Y Y N, Sun Y. Effects of stirring time on anaerobic digestion of cattle manure-corn stover: Microbial diversity and metabolic pathways. Fuel, 2024; 367: 131468.
[4] Meng X H, Zhen F, Yang J C, Zhang Q G, Zhang Z Y, Qu B, et al. A multistage biogas slurry reflux and spray anaerobic digestion reactor for high solid anaerobic digestion: Performance and application evaluation. Energy Conversion and Management, 2024; 321: 119060.
[5] Liu D, Cen R X, Yuan A, Wu M X, Luo C, Chen M M, et al. Effects of continuous low-speed biogas agitation on anaerobic digestion of high-solids pig manure: Performance and microbial community. Journal of Environmental Management, 2024; 354: 120355.
[6] Michelan R, Zimmer T R, Rodrigues J A D, Ratusznei S M, de Moraes D, Zaiat M, et al. Effect of impeller type and mechanical agitation on the mass transfer and power consumption aspects of ASBR operation treating synthetic wastewater. Journal of Environmental Management, 2009; 90（3）: 1357–1364.
[7] Alobaid F, Almohammed N, Massoudi Farid M, May J, Rößger P, Richter A, et al. Progress in CFD simulations of fluidized beds for chemical and energy process engineering. Progress in Energy and Combustion Science, 2022; 91: 100930.
[8] Pakzad L, Ein-Mozaffari F, Upreti S R, Lohi A. Evaluation of the mixing of non-Newtonian biopolymer solutions in the reactors equipped with the coaxial mixers through tomography and CFD. Chemical Engineering Journal, 2013; 215-216: 279–296.
[9] Cheng J P, Wu S, Wang X F, Shi Y F, Guo J B, Qiao N, et al. The dispersion of Trichosporon fermentans was controlled by optimizing the shear environment in the reactor to improve the cell sedimentation and separation performance. Journal of Cleaner Production, 2023; 414: 137649.
[10] Zhang Y, Yu G R, Yu L, Siddhu M A H, Gao M J, Abdeltawab A A, et al. Computational fluid dynamics study on mixing mode and power consumption in anaerobic mono- and co-digestion. Bioresource Technology, 2016; 203: 166–172.
[11] Singh B, Szamosi Z, Siménfalvi Z. Impact of mixing intensity and duration on biogas production in an anaerobic digester: a review. Critical Reviews in Biotechnology, 2020; 40（4）: 508–521.
[12] Rocamora I, Wagland S T, Villa R, Simpson E W, Fernández O, Bajón-Fernández Y. Dry anaerobic digestion of organic waste: A review of operational parameters and their impact on process performance. Bioresource Technology, 2020; 299: 122681.
[13] Dai X H, Hua Y, Li H P, Liu R, Chen S X, Dai L L, et al. Coupling self-sustaining air flotation screening with conventional CSTR enhances anaerobic biodegradability of corn stover. Bioresource Technology, 2020; 310: 123417.
[14] Kress P, Nägele H-J, Oechsner H, Ruile S. Effect of agitation time on nutrient distribution in full-scale CSTR biogas digesters. Bioresource Technology, 2018; 247: 1–6.
[15] Kariyama I D, Zhai X D, Wu B X. Influence of mixing on anaerobic digestion efficiency in stirred tank digesters: A review. Water Research, 2018; 143: 503–517.
[16] Lindmark J, Eriksson P, Thorin E. The effects of different mixing intensities during anaerobic digestion of the organic fraction of municipal solid waste. Waste Management, 2014; 34（8）: 1391–1397.
[17] Latha K, Velraj R, Shanmugam P, Sivanesan S. Mixing strategies of high solids anaerobic co-digestion using food waste with sewage sludge for enhanced biogas production. Journal of Cleaner Production, 2019; 210: 388–400.
[18] Ma S J, Xu K, Ren H Q. Effect of mixing intensity on volatile fatty acids production in sludge alkaline fermentation: Insights from dissolved organic matter characteristics and functional microorganisms. Journal of Environmental Management, 2023; 345: 118801.
[19] Li L L, Gao Q W, Wang K, Zhao Q L, Zhou H M, Jiang J Q, et al. Intermittent mixing facilitates energy recovery and low carbon emissions from high-solids anaerobic co-digestion of food waste and sewage sludge. Environmental Technology & Innovation, 2023; 32: 103339.
[20] Kelly W, Gigas B. Using CFD to predict the behavior of power law fluids near axial-flow impellers operating in the transitional flow regime. Chemical Engineering Science, 2003; 58（10）: 2141–2152.
[21] Liu Y Y N, Wang X G, Sun Y. Optimization and experimental study of variable frequency intermittent stirring strategy for anaerobic digestion based on CFD. Fuel, 2024; 355: 129371.
[22] Hreiz R, Adouani N, Fünfschilling D, Marchal P, Pons M-N. Rheological characterization of raw and anaerobically digested cow slurry. Chemical Engineering Research and Design, 2017; 119: 47–57.
[23] Wei L L, Ren Y M, Zhu F Y, Xia X H, Xue C H, Yang H Z, et al. Horizontal flow reactor optimization for biogas recovery during high solid organics fermentation: Rheological characteristic analyses. Journal of Water Process Engineering, 2021; 40: 101776.
[24] Dai X H, Gai X, Dong B. Rheology evolution of sludge through high-solid anaerobic digestion. Bioresource Technology, 2014; 174: 6–10.
[25] Yao Q W, Yang K, Zhang X X, Yin W L, Pan J X, Wang H, et al. Evaluation on the mixing state of solid-liquid two-phase in stirred tank via an improved Voronoi diagram approach. Powder Technology, 2025; 453: 120620.
[26] Wu Y Y, Chang X N, Zhang J W. Environmental emission evaluation for straw biogas power generation and bio-natural gas preparation based on LCA method. China Biogas, 2020; 38（01）: 59–65. （in Chinese）
[27] Siegert I, Banks C. The effect of volatile fatty acid additions on the anaerobic digestion of cellulose and glucose in batch reactors. Process Biochemistry, 2005; 40（11）: 3412–3418.
Downloads
Published
How to Cite
Issue
Section
License
Copyright (c) 2026 International Journal of Agricultural and Biological Engineering
This work is licensed under a Creative Commons Attribution 4.0 International License.
IJABE is an international peer reviewed, open access journal, adopting Creative Commons Copyright Notices as follows.
Authors who publish with this journal agree to the following terms:
- Authors retain copyright and grant the journal right of first publication with the work simultaneously licensed under a Creative Commons Attribution License that allows others to share the work with an acknowledgement of the work's authorship and initial publication in this journal.
- Authors are able to enter into separate, additional contractual arrangements for the non-exclusive distribution of the journal's published version of the work (e.g., post it to an institutional repository or publish it in a book), with an acknowledgement of its initial publication in this journal.
- Authors are permitted and encouraged to post their work online (e.g., in institutional repositories or on their website) prior to and during the submission process, as it can lead to productive exchanges, as well as earlier and greater citation of published work (See The Effect of Open Access).
